2017 Turbo Mist 450 Series S38P500S

2017 Turbo Mist 450 Series S38P500S

This product is intended for use on all size farms including large corporate farms with nuts or orchard trees that ideally will not extend above 20 freet in height. In California many growers use this series to spray almonds to a hight of 40 feet. The height that can be covered greatly depends upon the type of foliage and the speed of travel.

• Each unit has a painted stainless steel 30" turbine with adjustable air delivery and Turbomist air quality. The Turbomist turbine design compresses the air to gaurantee even distribution from both outlets. The front air intake has the added bonus of eliminating sand blasting of the fruit common in the rear intake competitors.

• Tanks 500 gallon and over are made of polished 304 stainless steel with 14 guage wraps and 12 guage inds.

• Standard pump is the Udor Zeta 170 (43 US Gal Volume with maximum pressure of 284PSI).

• High pressure Comet or Udor diaphragm pumps are available.

• 85 PTO Horse power is required for a unit with a 38" turbine.

• A tank cradling saddle system allows the frame to move independent of the tank and therefore greatly extends the tank life. 10 Year Warranty (5 Years full warranty, Pro-rated after 5years by 10% starting at 50% Warranty at the 6th year. )

• All diaphragm equipped units in the series have the Turbomist Offset Reduction Drive which protects your pump from over speeding the PTO. At a PTO speed of 540 RPM the pump is operating at 450 RPM, meaning even if the PTO is overdriven to 6500 RPM your pump will stay below the 550 RPM critical opertating zone. This is done by use of either belt of chain depending on the model and option chosen. This prevents diaphragm pump failures by diverting the excess water pressure back to the tank during non-spraying modes.

• Optional Turbosteer is available on all models.

• All units have 55 series clutched drivelines by Weasler. (Run down clutch for PTO brake equipped tractors.

• If attaching this series to large (100 HP size) field type tractors please consider the PTO shaft length, You may need to add an adaptor to the tractor to increase the length by approximately 6 inches. Orchard tractors in the 65-85 HP range are the norm.

• Citrus towers and SSTowers are available to customize your unit.

• Teejet Electric valves with pressure adjust at the tractor seat are the standard controls offered on this series, optional without pressure adj.